YFGW410现场无线管理站

YFGW410现场无线管理站以国际自动化协会(ISA)的工业自动化无线通信标准ISA100.11a为基准。该产品具有符合ISA100.11a标准的系统管理/安全管理/网关功能,与现场无线接入点(YFGW510)和/或现场无线媒体转换器(YFGW610)组合,构成现场无线系统。

  • 高度的可靠性和灵活性

    采用分离型结构,通过连接两台本产品实现冗余配置。运行中的现场无线系统无需停车,即可在线进行维护,运行高度灵活。

  • 高度安全的通信

    该产品支持访问控制列表(IP过滤器和端口过滤器)。根据不同角色的设置的密码可以保护用户界面的安全,防止恶意访问。符合ISA100.11a标准的端到端通信使用AES 128位进行加密。通过Achilles 1级认证,通信和安全的稳定性得到了验证。

  • 多协议通道

    该产品兼容如HART和Modbus的外部协议,并在设备和主机系统之间传输。 通过在安全仪表系统(SIS)和无线安全设备之间传输PROFIsafe等安全通信协议,实现整个安全系统所需的安全完整性等级(SIL)。

  • 无线资源的高效利用

    该产品可以灵活利用现场无线网络的带宽,实现可靠、高效的无线通信。 Duocast功能可以与连接到此产品的两个主干路由器(BBR)同时接收数据。内置的数据缓存功能可以节省现场无线网络的带宽和现场无线设备的能耗。

详细介绍

通信接口 标准 100Base-TX2
传输速度 100Mbps
接头 RJ-45
电缆类型 类别5
最大长度 100m
端口数 4个端口
端口名称 B1、B2、B3、B4
保护 Surge
通信协议 Modbus
OPC1
管理/配置等 HTTP
IEEE1588PTP v2
横河专用3
  1. 使用OPC接口连接时,需要现场无线设备OPC服务器(SSS7100)。有关该产品的详细信息,请参阅相关产品的一般规格书(GS)。
  2. 在室外接线至现场网络或现场无线主干网100BASE-TX时,使用非金属拉力构件的光纤连接YFGW610。
  3. 以TCP为基础的定制协议用于本产品与“现场无线OPC服务器”、“FieldMate通用设备管理工具”、“工厂资源管理系统(PRM)”和YFGW510之间的通信。有关各产品的详细信息,请参阅相关产品的一般规格书(GS)。
  4. 维护/诊断网络(100BASE-TX、RS-232C)不能用于室外接线。
  5. 这些仅为横河电机维护用的串行端口。
通信接口 标准 100Base-TX4 RS-232C4 5
传输速度 100Mbps 115.2kbps
Connector RJ-45 RJ-11
Cable Type 类别5 横河专用
Maximum 100m 15m
Number of Ports 1个端口 1个端口
Port Name M1
保护
通信协议 Modbus
OPC1
管理/配置等 HTTP横河专用3
  1. 使用OPC接口连接时,需要现场无线设备OPC服务器(SSS7100)。有关该产品的详细信息,请参阅相关产品的一般规格书(GS)。
  2. 在室外接线至现场网络或现场无线主干网100BASE-TX时,使用非金属拉力构件的光纤连接YFGW610。
  3. TCP为基础的定制协议用于本产品与“现场无线OPC服务器”、“FieldMate通用设备管理工具”、“工厂资源管理系统(PRM)”和YFGW510之间的通信。有关各产品的详细信息,请参阅相关产品的一般规格书(GS)。
  4. 维护/诊断网络(100BASE-TX、RS-232C)不能用于室外接线。
  5. 这些仅为横河电机维护用的串行端口。

 


 

功能规格 温度范围 运行时:-40 to +65°C(海拔高度:最高2000米)
-40 to +55°C (海拔高度:高于2000米,最高3000米)
存储时: -40 to +85°C
湿度范围 运行时:5 to 95 %RH (无结露)
存储时:5 to 95 %RH (无结露)
温度变化率 运行时:±10°C/h
存储时:±20°C/h 
电源 电压范围:10.8~26.4 V DC
额定电源: 24 V DC
瞬时断电: 瞬时断开连接
直流电源波速比:≤1%p-p 
功耗 最大10 W
保护等级 IP20
抗振性 0.15 mm P-P (5~58 Hz), 1 G (58~150 Hz)
耐冲击性 15 G 11 ms
抗干扰性 电场:≤3 V/m (80MHz~1GHz)
静电放电:≤ 4 kV(接触放电)、 8 kV(空气放电)
接地 D级接地(不要与其他仪表共用接地线)
冷却方式 自然空气冷却
强制合规性声明

CE一致性

EMC: EN61326-1 Class A, Table 2, EN55011 Class A group1, EN61000-6-2
安全要求 CSA C22.2 No. 61010-1 (仅用于室内)
防爆类型 ATEX认证n类声明
Co通信接口rface 标准 100BASE-TX2 RS-4853
传输速度

100Mbps
自适应)

38400, 19200, 9600 bps

接头 RJ-45 横河专用
电缆类型 类别5 AWG24~12
最大长度 100m 1200m
端口数 3个端口 1个端口
端口名称 F1、F2、F3
保护 浪涌 绝缘、浪涌保护
Co通信协议tocol

I/O数据和状态

Modbus/TCP
OPC 1 3
横河专用

Modbus/RTU

管理/配置等

HTTP
NTP/SNTP
横河专用3

  1. 使用OPC接口连接时,需要现场无线设备OPC服务器(SSS7100)。有关该产品的详细信息,请参阅相关产品的一般规格书(GS)。
  2. 在室外接线至现场网络或现场无线主干网100BASE-TX时,使用非金属拉力构件的光纤连接YFGW610。
  3. 以TCP为基础的定制协议用于本产品与“现场无线OPC服务器”、“FieldMate通用设备管理工具”、“工厂资源管理系统(PRM)”和YFGW510之间的通信。有关各产品的详细信息,请参阅相关产品的一般规格书(GS)。

参考

概述:

Wireless Multi-Input Temperature Transmitter YTMX580 can accept inputs from up to 8 points, and contribute to your CAPEX cost reduction.

行业:
概述:

Eliminating the wire using wireless transmitter is the perfect solution for rotating equipment. It establishes data collection between the transmitter and the gateway by reliable communication even though the dryer was rotating.

行业:
概述:

One important risk to manage with regard to coal stacks is preventing fires due to spontaneous combustion.

行业:
概述:

Install a YTMX580 on the side of the rotating furnace that can wirelessly transmit measured values from multiple temperature sensors.

行业:
概述:
  • Temperature is monitored to maintain consistency of the viscous fiber entering the drum.
  • Existing system requires manual temperature readings.
  • Wired temperature measurement is not available because the tank is rotating.
行业:
概述:

Delayed Coker is a type of coker who's process consists of heating residual oil feed to its thermal cracking temperature in a furnace. The most important variable in industrial furnace control is temperature. Temperature is measured throughout the furnace in different zones and temperature effects the materials being manufactured and therefore must be precisely monitored to prevent deviations in quality of the final product.

概述:

Challenges

  • The distance is not so long, but there are many pipes and tanks ("Pipe Jungle") in the field.
  • Had to avoid the obstacles and take care multi path condition.  

Solution

Repeater is installed on high place between control room and monitor position. The extend cable is used for antenna of Gateway.

  • Temperature Transmitter (YTA) x1, Pressure Transmitter (EJX) x2
概述:

Blending plays a key role in industries such as food, healthcare and chemicals etc. Temperature and vacuum measurements are very important in minimizing the moisture content to ensure the quality of the final product. Strictly maintaining them throughout the process ensures the final product yield.

行业:
概述:

The client wanted to monitor the pressure of the gas well at offshore platform remotely to reduce maintenance cost and increase safety of maintenance personnel.

概述:

ISA100 wireless temperature and pressure transmitters with orifice plates allow:

  • No cabling installations or maintenance.
  • Small amount of hardware and simple equipment implementation means minimizing potential vandalism.
行业:
概述:

ISA100 Wireless Monitoring  

  • Gateway x1, Temperature Transmitter (YTA) x3, Pressure Transmitter (EJX) x1, Repeater x1

Gateway is installed at control room and 3m height extended antenna is set.

行业:
概述:
  • Daily manual reading of pressure and temperature gauges with report by phone.
  • The customer wants to change measurement from off-line to on-line.
  • Cabling for wired transmitters in huge plants (up to 300 meters long) is expensive.
行业:
概述:

Direct Reduction Iron (DRI) is one of the processes to reduce oxygen from iron oxide pellets for steel plant. More than 90% of DRI processes use heated LNG as process gas where PID control for temperature or interlock control is of vital importance.

行业:
概述:

Pressure measurement of tubeless tyres to monitor the air loss is one of the key performance tests in the tyre manufacturing units. Relocation of tyres from one testing rack to the other for various tests and frequent movement of the testing setup for conditional tests to various locations calls for cable free implementation for ease of handling.

行业:
概述:
  • Temperature Transmitter (YTA) and Pressure Transmitter (EJX) are installed at each monitoring point.
  • Repeater is installed on high position.
行业:
概述:

ISA100 wireless temperature and pressure transmitters.

概述:
  • Oil level measurement of diesel tanks that feed fuel to their diesel generator's which are at three locations and 400 meters apart from each other.
  • Also to measure level , pressure and flow to and from their main storage yard.
行业:
概述:

ISA100 Wireless Temperature and Pressure Transmitters

  • Gateway x1, Temperature Transmitter (YTA) x1, Pressure Transmitter (EJX) x1

High quality wireless communication confirmed

  • Packet Error Rate (PER) is 0 to 2.5%/ 5 days
概述:
  • Manual temperature reading requires walking about 130 m and climbing up and down elevated sections of the dryer stages.
  • Multiple temperature measurement points along the various stages of the dryer require many cables to the control room.
  • Very high humidity.
行业:
概述:
  • Wireless temperature measurement 
    gateway x1, transmitter (YTA) x1
    repeater x1: between gateway and YTA.
  • High quality wireless communication was confirmed.
    With repeater at center: The packet error rate was 0%.
行业:
概述:
  • Wireless temperature measurement
    Gateway x1, transmitter (YTA) x1, repeater x2 (The 2 repeaters are for redundancy)
  • Extended antenna to circumvent obstacles and improve the radio path for stable measurement (communication was unstable when the height of the antenna was low).
行业:
概述:

Geothermal power plants create electricity from geothermal energy. These power plants are similar to other steam turbine station; however their heat source is that of the earth's core. The created steam is used to turn the turbine for the production of electricity. Technologies include Dry steam, Flash steam and Binary cycle power stations with Binary cycle being the most common geothermal plant in current production. In the process of geothermal power generation the facility needs to monitor various processes, as in this case steam line pressure sits in remote from control room's location.

概述:

A horizontal rotary miller used to grind the limestone rocks with metallic balls as grinding stones. This is used as the raw ingredient to produce cement powder. The temperature needs to be monitored in order to control the process and the quality of the final product. The user was using an induction temperature measurement based on a rail system that was very fragile and therefore unreliable.

行业:
概述:
  • Wireless pressure and temperature monitoring.
  • Repeater was set under the gateway.
  • The maximum distance between the repeater and transmitters is approximately 500m.
行业:
概述:

The client wanted to monitor the injection gas pressure of gas lift remotely in central control room. Antitheft measures are needed to install new equipments and cables.

概述:

Both bulk and finished inventories are stored in distributed tank farm remote from the site operations. These are difficult to instrument due to the infrastructure cost involved. These are then monitored daily by patrol rounds. While effective, this method does require a large skilled labor force to monitor all of tanks. This can impose an additional risk when the stored medium is of a hazardous nature.

行业:
概述:

Wireless technology has a long history, and it began around the time that James C. Maxwell theoretically predicted and then proved the existence of electromagnetic waves in the 1860s, and when Heinrich R. Hertz experimentally confirmed the actual existence of the electromagnetic wave in 1888.

概述:

In plant sites, there are various places such as those affording an unobstructed view like tank yards, and others surrounded by metal pipes and equipment obstructing the view (hereafter referred to "pipe jungles"), often seen in oil refinery and chemical on-site plants. The frequency band of radio waves used for field wireless communication is 2.4 GHz, which has high straightness and its ability to go around things can hardly be expected.

横河技报
概述:

The introduction of wireless technologies into plants is anticipated as one of the measures for implementing field digital solutions not only to reduce cable wiring costs but also to improve plant wide safety/stable operations, operating efficiency, and so on.

横河技报
概述:

The FieldMate versatile device management wizard is PC software mainly used for configuring and adjusting field devices. Under the concept of "one tool for all," Yokogawa has been enhancing this software to support a wide range of field devices and field communication protocols.

概述:

In recent years, expectations for control systems using wireless communications have been increasing in the process control market. This is because these systems do not require power and communication wiring for field instruments, enabling reduced initial and maintenance costs, and easy installation.

下载

想要了解更多的信息,技术&解决方案?

联系我们

置顶
WeChat QR Code
横河电机(中国)有限公司