Percent Concentration Sensors ISC40
เครื่องวิเคราะห์ของเหลว

Conductivity measurement is a reliable indicator of the concentration of most acid or base solutions. The desired chemical concentration is achieved using a two stage mixing procedure. During the first stage, the flow ratio control unit on the missing tank is set to provide (x) gallon per minute of the full strength solution and (y) gallons per minute of water. These values are adjusted to produce a concentration value which is slightly weaker than the desired value. This ratio control must include alarm capabilities to indicate "low flow" conditions for both the full strength solution and the water in order to prevent wasted chemicals or hazardous situations. 

At the second stage, a conductivity sensor and analyzer function as a "trim control". This combination adds small amounts of full-strength solution to the mixing tank to produce the exact concentration desired.

For example, to produce a 4% caustic solution from a large bulk caustic supply at 50%, the flow ratio controller is adjusted to make a 3% solution and the conductivity information is used to add additional caustic to achieve the 4% concentration.

 เส้นโค้งความเข้มข้นเปอร์เซ็นต์

Conductivity is a very reliable index of the concentration for most acid and base (caustic) solutions. Figure 1 shows the correlation between conductivity and concentration for four common solutions. 

รายละเอียด

For most solutions, there is a peak conductivity value. Before this peak value is reached, conductivity correlates positively with concentration; after the peak, it correlates negatively. So, if the concentration range passes through the peak for that chemical the conductivity value (except the peak value) represents two different concentration values. Therefore, it is mandatory that any application near the peak of a particular solution be carefully controlled.

In determining the proper loop components for a particular application, the material of construction will be of primary concern. A chemical resistance chart should be consulted (see Table 1), or an application data sheet completed and sent to the factory in order to insure an installation that will be suited for the intended application.

มีรูปแบบเซ็นเซอร์พื้นฐานสองแบบที่ใช้สำหรับการวัดค่าการนำไฟฟ้า: การสัมผัส และ อุปนัย (Toroidal, Electrodeless)

ด้วย การนำไฟฟ้าแบบอุปนัย (เรียกอีกอย่างว่า Toroidal หรือ Electrodeless) องค์ประกอบการตรวจจับ (ขดลวดอิเล็กโทรด) ของเซ็นเซอร์อุปนัยจะไม่สัมผัสโดยตรงกับกระบวนการ ขดลวดที่จับคู่ (เหมือนกัน) ทั้งสองนี้ถูกห่อหุ้มด้วย PEEK (หรือเทฟลอน) เพื่อปกป้องพวกมันจากผลกระทบที่ไม่พึงประสงค์ของกระบวนการ

มีเซลล์แฟกเตอร์ (ค่าคงที่) เพียงเซลล์เดียวสำหรับ ISC40 Inductive Sensor ครอบคลุมเกือบตลอดช่วงการวัดค่าการนำไฟฟ้า ~ 50-2,000,000 µS / cm. เฉพาะที่ระดับต่ำสุด (ต่ำกว่า 50 µS) เท่านั้นที่จะได้รับความแม่นยำของเซ็นเซอร์

Because the ISC40 Inductive sensor is virtually maintenance free; it is the first choice for any application.  If the ISC40 cannot be used then it is recommended to use the 4-electrode design, model SC42 large bore sensor. 

The model ISC40 sensors are designed for use with the EXA ISC analyzers. This combination exceeds all expectations for conductivity measurement in terms of reliability, accuracy, rangeability and price performance. 

ความแม่นยำคือ 0.5% ของการอ่านบวก 0.5 ไมโครวินาที / ซม. สำหรับค่าการนำไฟฟ้าใด ๆ ไม่ว่าจะวัดในน้ำล้างหรือในกรดเข้มข้น วัสดุในการก่อสร้างช่วยให้มั่นใจได้ถึงอายุการใช้งานที่ยาวนานภายใต้สภาวะอุตสาหกรรมที่รุนแรง

PEEK (Poly Ether Ether Ketone) ที่ทนต่อการสึกกร่อน / การสึกกร่อนซึ่งมีคุณสมบัติทนต่อสารเคมีได้ดีเยี่ยมในทุกสารละลายยกเว้นกรดฟลูออริกหรือกรดเข้มข้นออกซิไดซ์ วัสดุที่ดีที่สุดในแง่ของความทนทานต่อสารเคมีคือ PFA (เทฟลอน) สำหรับการใช้งานในกรดไฮโดรฟลูออริกและกรดเข้มข้นออกซิไดซ์ (ไนตริกซัลฟิวริกโอเสื่อน้ำมัน)

ISC40G และ ISC40s มีจำหน่ายใน PEEK (ประเภทเซ็นเซอร์ GG) สำหรับการใช้งานทั่วไป ในแอพพลิเคชั่นที่ตัวอย่างมีความก้าวร้าวต่อ Peek เราขอเสนอเซ็นเซอร์เป็น Teflon (Sensor type TG)

เซ็นเซอร์ ISC40 มาพร้อมกับเกลียวยึดสเตนเลสสตีลน็อตและปะเก็นที่ทนทานเพื่อความยืดหยุ่นสูงสุดในการติดตั้งโดยใช้เทคนิคการติดตั้งหัวแบบจำนวนมาก นอกจากนี้ยังมีตัวยึดและตัวเลือกมากมายสำหรับการติดตั้งแบบอินไลน์หรือออฟไลน์ที่เชื่อถือได้พร้อมซีลโอริงสองชั้นเพื่ออายุการใช้งานที่ยาวนานของเซ็นเซอร์ มีรุ่นเพิ่มเติมสำหรับใช้ในแอพพลิเคชั่น Ball-Valve Insertion และในการติดตั้ง Sanitary Flange

เซ็นเซอร์ทั้งสองมีรูเจาะขนาดใหญ่เพื่อความต้านทานที่ดีที่สุดต่อกระบวนการเปรอะเปื้อนและเมื่อติดตั้งอย่างเหมาะสมการไหลจะทำให้เซ็นเซอร์สะอาดเพื่อป้องกันข้อผิดพลาดในการวัด

  • เทคนิคการนำไฟฟ้าแบบอุปนัยเพื่อกำจัดข้อผิดพลาดของการเปรอะเปื้อนและโพลาไรซ์
  • เซ็นเซอร์เจาะกว้างเพื่อความเสถียรในระยะยาว
  • ความยืดหยุ่นในการติดตั้งโดยผู้ถือที่หลากหลายและโดยการใช้โครงสร้างกั้นแบบสากล
  • ความสามารถในการนำไฟฟ้าได้หลากหลาย (1 μS / cm ถึง 2 S / cm) และอุณหภูมิ (-20 ถึง130ºC)
  • การใช้งานทั้งหมดที่อิเล็กโทรดเปรอะเปื้อนอย่างรุนแรงจะป้องกันการใช้อิเล็กโทรดสัมผัส
  • ทุกช่วงยกเว้นการใช้งานน้ำบริสุทธิ์ (พิเศษ)
  • การใช้งานถนนลาดยางทั้งหมดที่ระบบทั่วไปต้องทนทุกข์ทรมานจากการอุดตันหรือการสึกกร่อน

All applications where the 6 decade rangeability is necessary for accurate process control

ผู้ถือ ISC40FF / ISC40FS / ISC40FD

This program includes flow fittings and their subassemblies for in-line or direct mounting of conductivity sensors in piping systems. A wide choice of construction materials gives the user the best solution for any process considering chemical resistance, pressure and temperature specifications.

  • มีวัสดุก่อสร้างให้เลือกมากมาย
  • มาตรฐานระดับสูงสำหรับทุกเซลล์
  • ติดตั้งบริการและถอดหรือเปลี่ยนเซ็นเซอร์ได้ง่าย
  • การออกแบบสแตนเลสสตีลขัดเงาด้วยไฟฟ้าเพื่อความต้านทานการกัดกร่อนที่ดีที่สุด
  • ใช้ได้กับอะแดปเตอร์หน้าแปลน

รุ่น PR10 ที่วาง "Hot-Tap" แบบพับเก็บได้

On-line measurements often present extra challenges, especially when routine maintenance is required. The PR10 is ideally suitable for applications where the sensors must be removed without interrupting or shutting down the process. Without any special tools the PR10 can be retracted safely from the process at pressures up to 5 bar (72 psi). The PR10 is a universal retractable assembly that can be used for all liquid measurements. The PR10 is designed to accept any commercially available pH/ORP or dissolved oxygen sensor that has a PG13.5 connection while still being backwards compatible with old Yokogawa electrodes.

เพื่อความสะดวกในการใช้งานพอร์ตฟลัชเสริมที่มีอยู่ ในตำแหน่งที่หดกลับเซ็นเซอร์สามารถเก็บรักษาความชื้นทำความสะอาดหรือแม้แต่ปรับเทียบได้ ทั้งหมดนี้สามารถทำได้โดยไม่มีการหยุดชะงักของกระบวนการหรือการถอดชิ้นส่วนกระดอง

  •  One model for pH/ORP, dissolved oxygen, conductivity and inductive conductivity sensors
  • สามารถติดตั้งอิเล็กโทรด pH ที่มีจำหน่ายทั่วไปเช่น PG13.5, เซ็นเซอร์ SMART, Vario Pin, YEF และ DIN ใน PR10
  • กรงป้องกันแบบบูรณาการ
  • "มีดโกน" ติดตั้งไว้ในแต่ละชุดเพื่อขูดหรือเช็ดออกอย่างมีประสิทธิภาพ
    กระบวนการจากเพลาของ PR10 ขณะที่กำลังถูกดึงออกจากกระบวนการ
  • การออกแบบการใส่และการดึงออก "ผ่านวาล์ว" ที่ปลอดภัย
  • ติดตั้งง่ายด้วยบอลวาล์วเสริมที่มีการเชื่อมต่อแบบหน้าแปลนหรือแบบเรียว
  • อุปกรณ์เสริมพอร์ตล้างทำให้ง่ายต่อการดูแลเซ็นเซอร์ให้ชื้น (pH) และทำความสะอาดและยังช่วยให้เข้าถึงการสอบเทียบได้หากต้องการ

โซลูชันมาตรฐานการสอบเทียบ

โยโกกาวา จัดหามาตรฐานการเอื้อต่อแฮมิลตันซึ่งรับประกันความเสถียร± 1% ตลอดอายุการใช้งาน 1 ถึง 3 ปีขึ้นอยู่กับค่า


 

แหล่งข้อมูล

Overview:

มีการใช้งานทางอุตสาหกรรมจำนวนมากที่การวัดและ / หรือการควบคุมความแข็งแรงทางเคมีเฉพาะของกระบวนการเป็นสิ่งสำคัญสำหรับการเพิ่มประสิทธิภาพการผลิตผลิตภัณฑ์ขั้นสุดท้าย ความเข้มข้นเฉพาะเหล่านี้ได้มาจากการผสมสารละลายที่มีความเข้มข้นเต็มที่กับน้ำเพื่อให้ได้ความเข้มข้นเปอร์เซ็นต์ที่ต้องการ

ดาวน์โหลด

วิดีโอ

คุณต้องการข้อมูลเพิ่มเติมเกี่ยวกับบุคลากร เทคโนโลยี และโซลูชั่นของเราหรือไม่ ?

ติดต่อเรา

ด้านบน